The main principle of vertical cyclone separator is to filter dust and flue gas by blocking the bag, which can achieve a purification effect. The national standard emission and pulse dust removal effect are also very good. The small dust remover is online dust removal, which can also be explained as pulse jet blowing the bag of the dust remover when collecting dust and flue gas. This is the small dust remover.
Vertical cyclone separator is mainly used for small boilers, furniture factories, local dust points or as a dust collector for a certain equipment dust point. It is composed of fans, purification rooms, filter rooms, cone buckets, flower plates, air receivers, pulse valves, blowing pipes, frameworks, filter bags, control boxes, guardrails, stairs, etc. The vertical cyclone separator has good dedusting effect, high dedusting efficiency, small floor area, low energy consumption, easy installation, easy maintenance, convenient filter bag replacement, long service life of filter bag and skeleton, and can be designed as ash bucket trapezoid or dust collector plus wheel mobile type.
The vertical cyclone separator shall be used in a dry room or similar environment with an altitude of no more than 1000m, good ventilation, an ambient temperature of no more than 40 ℃, and no flammable or corrosive gas in the air. Before using the vertical cyclone separator, the hose shall be properly connected with the suction port of the shell. The hose shall be tightly connected with each super long pipe and the suction nozzle at the end of the pipe, such as furniture brush, gap suction nozzle, floor brush, etc. Because there are few air inlets of the slot nozzle, the noise is high when using, and the continuous use time should not be too long.
The vertical cyclone separator shall be grounded to ensure the safety of electricity use. The continuous use time shall not exceed 1 hour each time. The continuous use time of industrial vacuum cleaner shall not exceed 8 hours each time to prevent the motor from being burnt out due to overheating. When using the vacuum cleaner equipped with an automatic wire winding device, pull out the power cord to a sufficient length. Do not pull the power cord too far. If there are yellow or red marks on the power cord, That is to stop pulling out. When the vertical cyclone separator needs to rewind the power cord, press the button to automatically retract it.
When using vertical cyclone separator, pay attention not to make the vacuum cleaner wet, and do not operate the machine with wet hands. If there are large pieces of paper, paper balls, plastic cloth or things larger than the diameter of the straw in the cleaned place, they should be eliminated in advance, otherwise the suction pipe may be blocked.
vertical cyclone separator https://www.kaisenfilter.com/Cyclone-Separators.html
Comments (0)